礁灰岩油藏微粒过饱和充填技术机理及创新实践

doi:10.11885/j.issn.1674-5086.2020.07.15.01

摘要/Abstract

摘要： 南海东部地区流花油藏为礁灰岩油藏，按其内部结构特点，包括基质、裂缝及溶孔三重介质。油井含水上升速度快，各项常规增产技术均无明显效果。该油田在“微粒环空充填技术”的基础上，在业内首次创造性提出并尝试了“微粒过饱和充填技术”，已实施的3口井均取得明显效果，在保证产能的同时，含水率比邻井低30%以上，且含水上升速度慢，预测该技术单井增油5× 10⁴ m³。但由于礁灰岩油藏地质油藏条件的复杂性，该技术应用的作用机理多有争论。因此，综合裂缝特征、渗流力学、油藏工程、完井工艺、数值模拟等研究，进行了礁灰岩油藏“微粒过饱和充填技术”的作用机理研究，认为起到“控水、堵缝、储层改造”三重作用，早期以储层改造为主、一定程度起到堵缝作用，相对高压充填微颗粒对近井储层起到扩张微裂缝、沟通更多基质储层、增大波及范围，后期以控水为主。该研究将指导本油田对微粒过饱和充填的后续应用，以及对其它裂缝性礁灰岩油田或者底水砂岩油田的控水增产具有较强的指导意义。

关键词: 礁灰岩, 三重介质, 微粒过饱和充填, 裂缝充填, 储层改造

Abstract: Liuhua reservoir in the east of South China Sea is a limestone reservoir, with a three-medium porous system, including matrix, fracture and pore. The water cut of oil wells goes up very fast. Various methods have been tried to solve this problem, but few effects have been achieved very. Based on the common particles filling technique, an over-saturated continuous pack-off technique is proposed and three wells have achieved obvious results. The water cut was 30% lower than adjacent wells and goes up much slower, the estimated ultimate recovery is 50 thousand m₃ more than designed. Due to the complexity of the geological and reservoir conditions, the mechanisms of this technique is controversial. This paper, based on the study of fractures, porous flow features, reservoir engineering method, well completion and reservoir simulation, studies the mechanisms of over-saturated particles, which are water control, fracture plug and formation remolding. At early stages, the main mechanism is formation remolding and fracture plug, over-saturated continuous pack-off injection amplifies the micro-fractures and connect the matrix. At later stages, water control is the main mechanism. This study will guide the further application of this technique to limestone reservoir and other bottom-water driven sandstone reservoirs.

Key words: limestone reservoir, triple media, over-saturated particles, fracture plug, formation remolding

中图分类号:

TE34

杨勇, 李锋, 张伟, 谢日彬, 李小东. 礁灰岩油藏微粒过饱和充填技术机理及创新实践[J]. 西南石油大学学报(自然科学版), 2022, 44(4): 129-138.

YANG Yong, LI Feng, ZHANG Wei, XIE Ribin, LI Xiaodong. The Mechanisms and Innovative Applications of Over-saturated Particles Well Completion Technique in Limestone Reservoir[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2022, 44(4): 129-138.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal15.magtechjournal.com/Jwk_xnzk/CN/10.11885/j.issn.1674-5086.2020.07.15.01

http://journal15.magtechjournal.com/Jwk_xnzk/CN/Y2022/V44/I4/129

参考文献

[1] 刘伟新, 宁玉萍, 王华, 等.双重介质定量描述技术在复杂礁灰岩油田开发中的应用——以珠江口盆地流花4-1油田为例[J].中国海上油气, 2014, 26(3):65-71.%doi:LIU Weixin, NING Yuping, WANG Hua, et al. The application of the technique of quantitatively characterizing double-porosity medium in the development of complex reef-limestone oilfields:A case of LH4-1 Oilfield, Pearl River Mouth Basin[J]. China Offshore Oil and Gas, 2014, 26(3):65-71.
[2] 李楚吟, 吴意明, 张永江, 等.南海礁灰岩油藏裂缝电阻率成像特征分析及评价[J].石油天然气学报, 2012, 34(10):72-76. doi:10.3969/j.issn.1000-9752.2012.10.017 LI Chuyin, WU Yiming, ZHANG Yongjiang, et al. Characters of resistivity image in reef limestone reservoir fracture evaluation in the South China Sea[J]. Journal of Oil and Gas Technology, 2012, 34(10):72-76. doi:10.3969/j.issn.1000-9752.2012.10.017
[3] 宁玉萍, 王峻峰, 罗东红, 等.流花油田礁灰岩储层微观性质及驱替特征研究[J].西南石油大学学报(自然科学版), 2017, 39(6):34-44. doi:10.11885/j.issn.1674-5086.2017.09.04.02 NING Yuping, WANG Junfeng, LUO Donghong, et al. Study on the displacement characteristics and micro scopic properties of the reef limestone reservoir in Liuhua Oilfield[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2017, 39(6):34-44. doi:10. 11885/j.issn.1674-5086.2017.09.04.02
[4] 谢日彬, 李海涛, 杨勇, 等.礁灰岩油田水平井微粒充填ICD均衡控水技术[J].石油钻采工艺, 2019, 41(2):160-164. doi:10.13639/j.odpt.2019.02.007 XIE Ribin, LI Haitao, YANG Yong, et al. Particle filling based ICD isostatic water control technology used for ho-rizontal wells in limestone reef oilfields[J]. Oil Drilling & Production Technology, 2019, 41(2):160-164. doi:10.13639/j.odpt.2019.02.007
[5] 张杰, 康志江, 张允, 等.缝洞型碳酸盐岩油藏油井出水特征及影响因素分析[J].中国石油大学胜利学院学报, 2011, 25(3):10-12. doi:10.3969/j.issn.1673-5935.2011.03.005 ZHANG Jie, KANG Zhijiang, ZHANG Yun, et al. Analysis on the characteristics and influencing factors of oil well water producing in fractured-vuggy carbonate reservoir[J]. Journal of Shengli College China University of Petroleum, 2011, 25(3):10-12. doi:10.3969/j.issn.1673-5935.2011.03.005
[6] 王利军, 刘传刚, 王丙刚, 等.海上油田水平井控水完井技术现状及发展趋势[J].石油矿场机械, 2017, 46(1):86-89. doi:10.3969/j.issn.1001-3482.2017.01.020 WANG Lijun, LIU Chuangang, WANG Binggang, et al. Status and development trend of horizontal well water-control completion technology for offshore oilfield[J]. Oil Field Equipment, 2017, 46(1):86-89. doi:10.3969/j.issn.1001-3482.2017.01.020
[7] 赵海峰, 田建超, 穆二飞, 等.水平井控水装置发展现状[J].石油矿场机械, 2017, 46(1):81-85. doi:10.3969/j.issn.1001-3482.2017.01.019 ZHAO Haifeng, TIAN Jianchao, MU Erfei, et al. Developing situation of water control device in horizontal wells[J]. Oil Field Equipment, 2017, 46(1):81-85. doi:10.3969/j.issn.1001-3482.2017.01.019
[8] 张建丰.水平井新型控水装置的设计与研究[D].成都:西南石油大学, 2017. ZHANG Jianfeng. Design and research of new type water control device for horizontal wells[D]. Chengdu:Southwest Petroleum University, 2017.
[9] 陈飞飞. ICD在水平井中控水调剖参数优选研究[D].成都:西南石油大学, 2016. CHEN Feifei. Research on parameter optimization for water control and profile control with ICD in horizontal wells[D]. Chengdu:Southwest Petroleum University, 2016.
[10] 邹伟林.水平井AICD完井技术研究[D].北京:中国石油大学(北京), 2016. ZHOU Weilin. A research on horizontal well completion technology with AICD[D]. Beijing:China University of Petroleum (Beijing), 2016.
[11] 朱橙, 刘华伟, 李登, 等. AICD管柱工艺在海上油田水平井中的控水效果分析[J].中国石油和化工标准与质量, 2016, 36(8):125-128. doi:10.3969/j.issn.1673-4076.2016.08.068 ZHU Cheng, LIU Huawei, LI Deng, et al. Analysis of water control effect of AICD string technology applied to horizontal wells in offshore oilfields[J]. China Petroleum and Chemical Standard and Quality, 2016, 36(8):125-128. doi:10.3969/j.issn.1673-4076.2016.08.068
[12] 刘明全, 冯全雄, 肖为, 等.流花11-1生物礁油田底水快速锥进研究[J].西南石油大学学报(自然科学版), 2015, 37(2):49-56. doi:10.11885/j.issn.1674-5086.2012.12.24.01 LIU Mingquan, FENG Quanxiong, XIAO Wei, et al. Fast coning of bottom water in bioherm oilfield of LH11-1[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2015, 37(2):49-56. doi:10.11885/j.issn.1674-5086.2012.12.24.01
[13] 王丙刚, 邢洪宪, 唐咸弟, 等.南海礁灰岩油藏自适应控水技术实验与分析[J].西部探矿工程, 2018, 30(12):49-52. doi:10.3969/j.issn.1004-5716.2018.12.016 WANG Binggang, XING Hongxian, TANG Xiandi, et al. Experiment and analysis of adaptive water control technology for reef limestone reservoir in South China Sea[J]. West-China Exploration Engineering, 2018, 30(12):49-52. doi:10.3969/j.issn.1004-5716.2018.12.016
[14] 陈献铭.水平井ICD完井控水增油效果数值模拟研究[D].成都:西南石油大学, 2014. CHEN Xianming. Numerical simulation study on water control and oil enhancement effort of horizontal well ICD completion[D]. Chengdu:Southwest Petroleum University, 2014.
[15] 朱迎辉, 陈维华, 代玲, 等.南海东部油田强底水油藏水平井开采特征及开采对策研究[J].石油地质与工程, 2016, 30(5):75-77. doi:10.3969/j.issn.1673-8217.2016.05.018 ZHU Yinghui, CHEN Weihua, DAI Ling, et al. Study on exploitation characteristics and countermeasures of horizontal well in reservoirs with strong bottom water in eastern oilfield of South China Sea[J]. Petroleum Geology and Engineering, 2016, 30(5):75-77. doi:10.3969/j.issn.1673-8217.2016.05.018
[16] 孙昕迪, 白宝君.国内外水平井控水技术研究现状[J].石油勘探与开发, 2017, 44(6):967-973. doi:10.11698/PED.2017.06.15 SUN Xindi, BAI Baojun. Comprehensive review of water shutoff methods for horizontal wells[J]. Petroleum Exploration and Development, 2017, 44(6):967-973. doi:10.11698/PED.2017.06.15
[17] 宁玉萍, 陈维华.底水油藏水平井中心管、ICD完井工艺技术[J].中外能源, 2014, 19(2):40-43. doi:10.3969/j.issn.1673-579X.2014.02.008 NING Yuping, CHEN Weihua. Pipe base and ICD completion technique of the horizontal wells in the bottom water reservoir[J]. Sino-Global Energy, 2014, 19(2):40-43. doi:10.3969/j.issn.1673-579X.2014.02.008
[18] 罗启源, 代玲, 陈维华, 等. ICD控水工艺技术在南海礁灰岩油田的应用与思考[J].长江大学学报(自科版), 2016, 13(32):68-73. doi:10.3969/j.issn.1673-1409(s).2016.32.014 LUO Qiyuan, DAI Ling, CHEN Weihua, et al. Application study of ICD water control technology in reef limestone reservoir of South China Sea[J]. Journal of Yangtze University(Nature Science Edition), 2016, 13(32):68-73. doi:10.3969/j.issn.1673-1409(s).2016.32.014
[19] 单彦魁.南海东部油田ICD控水完井工艺[J].西部探矿工程, 2018, 30(12):26-28. doi:10.3969/j.issn.1004-5716.2018.12.008 SHAN Yankui. ICD completion technique in Southeast China Sea[J]. Western Mining Engineering, 2018, 30(12):26-28. doi:10.3969/j.issn.1004-5716.2018.12.008