煤层气井有杆泵内煤粉沉积的影响因素分析

doi:10.11885/j.issn.16745086.2014.10.31.05

西南石油大学学报(自然科学版) ›› 2016, Vol. 38 ›› Issue (5): 143-150.DOI: 10.11885/j.issn.16745086.2014.10.31.05

煤层气井有杆泵内煤粉沉积的影响因素分析

莫日和¹, 张芬娜², 綦耀光², 何涌杰², 张国富²

1. 中联煤层气有限公司, 北京东城 100108;
2. 中国石油大学(华东)机电工程学院, 山东青岛 266580

收稿日期:2014-10-31 出版日期:2016-10-01 发布日期:2016-10-01
通讯作者: 张芬娜,E-mail:zhangfenna@163.com
作者简介:莫日和,1969年生,男,汉族,广东高州人,高级工程师,硕士,主要从事油气井、煤层气井钻井、压裂、排采技术研究。E-mail:morh998@163.com;张芬娜,1982年生,女,汉族,山东菏泽人,讲师,博士,主要从事煤层气排采工艺理论与方法、修井工艺理论以及增产措施方面的研究。E-mail:zhangfenna@163.com;綦耀光,1957年生,男,汉族,山东东营人,教授,博士生导师,主要从事煤层气井排采设备和工艺技术、机械设计及理论方面的研究。E-mail:qiyg57@126.com;何涌杰,1991年生,男,汉族,江苏泰州人,硕士研究生,主要从事机械设计及理论、抽油杆柱设计方法研究。E-mail:heyj91@163.com;张国富,1990年生,男,汉族,山东临朐人,硕士研究生,主要从事机械设计及理论、排采设备选型与优化研究。E-mail:zgf5337@163.com
基金资助:
国家自然科学基金（51174224）；国家科技重大专项（2011ZX05062004，2016ZX05066012）；中央高校基本科研业务费专项资金（16CX02004A）。

Movement of Pulverized Coal in Sucker Rod Pump in Coalbed Methane Well

MO Rihe¹, ZHANG Fenna², QI Yaoguang², HE Yongjie², ZHANG Guofu²

1. China United Coalbed Methane(CBM) Co. Ltd., Dongcheng, Beijing 100108, China;
2. School of Mechanical and Electric Engineering, China University of Petroleum, Qingdao, Shandong 266580, China

Received:2014-10-31 Online:2016-10-01 Published:2016-10-01

摘要/Abstract

摘要： 依据固液两相流理论，建立了煤层气井煤粉在有杆抽油泵内的数学模型，对煤粉在泵内的运动规律进行了分析，通过求解煤层气井有杆泵内固液两相流模型及仿真分析，得到了煤粉颗粒直径、井液的入泵速度及井液中煤粉颗粒浓度等参数对有杆泵内煤粉沉积的影响，利用固体颗粒在泵筒和柱塞间隙的磨损特性，分析了煤粉对有杆泵使用寿命的影响并给出了延长检泵周期，提高泵的使用寿命的措施。结果表明：有杆泵内下端煤粉浓度较大，分布非常不均匀；有杆泵内煤粉颗粒速度分布不均匀，湍流现象比较严重，煤粉颗粒主要沉积在固定阀入口两侧。煤粉粒径越小、井液入泵速度越大和井液中颗粒浓度越小可减少煤粉在有杆泵内的沉积。在排采的过程中通过连续、稳定、缓慢的降压，减少储层出煤粉；合理调节排采系统的冲程、冲次，通过改变泵的排量提高泵入口的流速，可减小煤粉在有杆泵内的沉积，使进入泵中的煤粉尽量排出泵外进入抽油杆和油管环空，以减少煤粉对有杆泵的影响。

关键词: 煤层气井, 有杆泵, 煤粉, 入泵速度, 使用寿命

Abstract: Based on the solid-liquid two phase flows theory, the mathematical model of coal particles in sucker rod pump was built, and the motion law of coal particles in sucker rod pump was analyzed. Through the model and simulation analysis of the solid-liquid two phase flows in sucker rod pump, the influence of the parameters, including the diameter of coal particles, the inlet velocity of well fluid, and the concentration of coal particles in well fluid, on coal particles deposition in sucker rod pump was obtained. Based on the wearing character of solid particles in the space between pump barrel and plunger, the influence of coal particles on service life of sucker rod pump was analyzed and the measures to prolong the detection period and service life of pump was given. The results show that the concentration of coal particles in the bottom of pump is relatively big and the distribution is very uneven. In sucker rod pump, the velocity distribution of coal particles is uneven and the turbulence is obvious, with coal particles mainly depositing along the entrance of the standing valve. A smaller diameter of coal particles, bigger inlet velocity of well fluid, and smaller concentration of coal particles in well fluid can reduce coal particles deposition in sucker rod pump. In the process of production, a continuous, stable and slow depressurization can reduce the production of coal particles. The reasonable adjustment of stroke and rate of production system and improvement of inlet velocity by changing pump capacity can reduce the coal particles deposition in sucker rod pump, making the coal particles in sucker rod pump discharged into the annulus between pumping rod and tubing, and the influence of coal particles on the pump can be significantly reduced.

Key words: coalbed methane well, sucker rod pump, pulverized coal, initial velocity, service life

中图分类号:

TE132.2

莫日和, 张芬娜, 綦耀光, 何涌杰, 张国富. 煤层气井有杆泵内煤粉沉积的影响因素分析[J]. 西南石油大学学报(自然科学版), 2016, 38(5): 143-150.

MO Rihe, ZHANG Fenna, QI Yaoguang, HE Yongjie, ZHANG Guofu. Movement of Pulverized Coal in Sucker Rod Pump in Coalbed Methane Well[J]. 西南石油大学学报(自然科学版), 2016, 38(5): 143-150.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal15.magtechjournal.com/Jwk_xnzk/CN/10.11885/j.issn.16745086.2014.10.31.05

http://journal15.magtechjournal.com/Jwk_xnzk/CN/Y2016/V38/I5/143

参考文献

[1] 万仁溥,罗英俊. 采油技术手册[M]. 北京:石油工业出版社, 1993:105-244.
[2] LIU Xinfu, QI Yaoguang, WU Jianjun, et al. An approach to the optimum design of sucker-rod pumping system[C]//International Conference On Information Engineering, 2010, 3:140-143.
[3] HIRSCHFELDT C M, RUIZ R. Selection criteria for artificial lift system based on the mechanical limits:Case study of Golfo San Jorge Basin[C]. SPE 124737, 2009.
[4] 齐俊林,郭方元,黄伟,等. 游梁式抽油机分析方法[J]. 石油学报, 2006, 27(6):116-124. QI Junlin, GUO Fangyuan, HUANG Wei, et al. Exact analysis on beam pumping unit[J]. Acta Petrolei Sinica, 2006, 27(6):116-124.
[5] 李琨,高宪文,仇治学,等. 有杆泵抽油系统井下工况诊断的物元分析方法[J]. 东北大学学报(自然科学版), 2013, 34(5):613-617. LI Kun, GAO Xianwen, QIU Zhixue, et al. Matterelement analysis method of downhole conditions diagnosis for suck rod pumping system[J]. Journal of Northeastern University(Natural Seienee),2013,34(5):613-617.
[6] 张宏录,刘海蓉. 中国页岩气排采工艺的技术现状及效果分析[J]. 天然气工业, 2012, 32(12):49-51. ZHANG Honglu,LIU Hairong. State of the art and effects of dewatering & recovery of shale gas in China[J]. Natural Gas Industry, 2012, 32(12):49-51.
[7] 敏政,王乐,邵翔宇. 泥沙颗粒直径及体积分数对高比转速离心泵的影响[J]. 兰州理工大学学报, 2009, 35(1):46-49. MIN Zheng, WANG Le, SHAO Xiangyu. Influence of silt particle diameter and volume fraction on centrifugal pumps with high specific speed[J]. Journal of Lanzhou University of Technology, 2009, 35(1):46-49.
[8] 李仁年,韩伟,刘胜,等. 小粒径固液两相流在螺旋离心泵内运动的数值分析[J]. 兰州理工大学学报, 2007, 33(1):55-58. LI Rennian,HAN Wei,LIU Sheng,et al. Numerical analysis of interior flow in screw centrifugal pump for liquidsolid two-phase medium with small size particles[J]. Journal of Lanzhou University of Technology, 2007, 33(1):55-58.
[9] 何伟强,李昳,张玉良,等. 固相体积分数对泵性能影响研究[J]. 浙江理工大学学报, 2010, 27(4):575-579. HE Weiqiang, LI Yi, ZHANG Yuliang, et al. Study on the influence of solid-phase volume fraction on performance of pump[J]. Journal of Zhejiang Sci-Tech University, 2010, 27(4):575-579.
[10] 朱祖超,崔宝玲,李昳,等. 双流道泵输送固液介质的水力性能及磨损试验研究[J]. 机械工程学报, 2009, 45(12):65-69. ZHU Zuchao, CUI Baoling, LI Yi, et al. Experimental study on hydraulic performance and wear of doublechannel pump delivering solid-liquid media[J]. Journal of Mechanical Engineering, 2009, 45(12):65-69.
[11] WEI X Y, LU Z R, WANG H Y, et al. The Discharge Characteristic Analysis and the Simulation of Axial Piston Pumps[J]. Advanced Materials Research, 2012, 490-495.
[12] 刘新福,吴建军,綦耀光,等. 煤层气井气体对有杆泵排采的影响[J]. 中国石油大学学报(自然科学版), 2011, 35(4):144-149. LIU Xinfu, WU Jianjun, QI Yaoguang, et al. Effect of gas on sucker rod pump for coalbed methane well[J]. Journal of China University of Petroleum, 2011, 35(4):144-149.
[13] MORSI S A, ALEXANDER A J. An investigation of particle trajectories in two-phase flow systems[J]. Fluid Mech, 1972, 55(2):193-208.
[14] 刘冰,杜继芸,綦耀光,等. 抽油机井杆管环空瞬态流场煤粉颗粒排出研究[J]. 中国石油大学学报(自然科学版), 2014, 38(1):117-123. LIU Bing, DU Jiyun, QI Yaoguang, et al. Research on coal particle carrying out in unsteady flow field of rod pumped well annulus[J]. Journal of China University of Petroleum, 2014, 38(1):117-123.
[15] 吴子牛. 计算流体力学基本原理[M]. 北京:科学出版社, 2001:15-52.
[16] 朱君,高源,王慧. 防冲距对抽油机井泵效的影响分析[J]. 油气田地面工程, 2009, 28(10):60-61. ZHU Jun, GAO Yuan, WANG Hui. Analysis of impingement distance the impact on pump efficiency of pumping unit well[J]. Oil-Gas Field Surface Engineering, 2009, 28(10):60-61.
[17] 张强,付云飞,袁智,等. 多相介质诱发柱塞泵内部磨损[J]. 科技导报2012, 30(6):44-47. ZHANG Qiang, FU Yunfei, YUAN Zhi, et al. Multimedium running induced piston pump erosion[J]. Science & Technology Review, 2012, 30(6):44-47.

煤层气井有杆泵内煤粉沉积的影响因素分析

Movement of Pulverized Coal in Sucker Rod Pump in Coalbed Methane Well

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	陈立超, 王生维, 张典坤, 郭丁丁, 任龙锋. 陇东地区煤层气井油管柱腐蚀机理研究[J]. 西南石油大学学报(自然科学版), 2020, 42(1): 170-180.
[2]	秦学成;段永刚;谢学恒;曹亚芹;康如坤. 煤层气井产气量控制因素分析[J]. 西南石油大学学报(自然科学版), 2012, 34(2): 99-104.
[3]	倪小明王延斌接铭训吴建光. 煤层气井排采初期合理排采强度的确定方法[J]. 西南石油大学学报(自然科学版), 2007, 29(6): 101-104.
[4]	杨志梁政祝新清许强邓雄 . 抽油机井合理下泵深度的优化设计[J]. 西南石油大学学报(自然科学版), 2007, 29(5): 149-151.