缝洞型碳酸盐岩油藏注气吞吐EOR效果评价

doi:10.11885/j.issn.1674-5086.2015.04.24.01

西南石油大学学报(自然科学版) ›› 2017, Vol. 39 ›› Issue (1): 133-139.DOI: 10.11885/j.issn.1674-5086.2015.04.24.01

缝洞型碳酸盐岩油藏注气吞吐EOR效果评价

苏伟^1,2,3,4, 侯吉瑞^1,2,3,4, 刘娟^1,2,3,4, 朱道义^1,2,3,4, 席园园^1,2,3,4

1. 中国石油大学(北京)提高采收率研究院, 北京昌平 102249;
2. 中国石油三次采油重点实验室, 北京昌平 102249;
3. 中国石油大学(北京)石油工程教育部重点实验室, 北京昌平 102249;
4. 中国石化海相油气藏开发重点实验室, 北京海淀 100086

收稿日期:2015-04-24 出版日期:2017-02-01 发布日期:2017-02-01
通讯作者: 苏伟,E-mail:532018851@qq.com
作者简介:苏伟,1990年生,男,汉族,江苏南通人,博士研究生,主要从事提高采收率与采油化学方面的研究。E-mail:532018851@qq.com;侯吉瑞,1965年生,男,汉族,吉林松原人,教授,博士生导师,主要从事化学驱原理与技术,深部调堵应用技术及相关机理,CO₂驱油相关理论与技术等方面的研究。E-mail:houjirui@126.com;刘娟,1990年生,女,汉族,黑龙江绥芬河人,硕士研究生,主要从事提高采收率与采油化学方面的研究。E-mail:liujuansfh@sohu.com;朱道义,1990年生,男,汉族,湖北武汉人,博士研究生,主要从事提高采收率与采油化学方面的研究。E-mail:zhu_daoyi@163.com;席园园,1992年生,女,汉族,山东聊城人,硕士研究生,主要从事提高采收率与采油化学方面的研究。E-mail:254643606@qq.com
基金资助:
国家科技重大专项（2011ZX05014-003）；国家重点基础研究发展计划（“973”计划）（2011CB201006）。

Evaluation of EOR Effect of Gas Huff-n-puff in Fractured Vuggy Carbonate Reservoirs

SU Wei^1,2,3,4, HOU Jirui^1,2,3,4, LIU Juan^1,2,3,4, ZHU Daoyi^1,2,3,4, XI Yuanyuan^1,2,3,4

1. Enhanced Oil Recovery Research Institute, China University of Petroleum(Beijing), Changping, Beijing 102249, China;
2. Key Laboratory Tertiary Recovery, CNPC, Changping, Beijing 102249, China;
3. MOE Key Laboratory for Petroleum Engineering, China University of Petroleum(Beijing), Changping, Beijing 102249, China;
4. SINOPEC Key Laboratory of Marine Oil & Gas Reservoir Production, Haidian, Beijing 100086, China

Received:2015-04-24 Online:2017-02-01 Published:2017-02-01

摘要/Abstract

摘要： 缝洞型碳酸盐岩稠油油藏以大型溶洞、溶蚀孔洞及裂缝为主要储集空间，非均质性极强，针对此类油藏，注气吞吐是一种有效的开发方式。为了探索缝洞型碳酸盐岩油藏注气吞吐开发效果，设计并制作了适用于缝洞型油藏吞吐室内物理模拟实验装置，从换油率、产气速率、产气量等方面对比分析了4种吞吐介质（CO₂、N₂、先注CO₂后注N₂、先注N₂后注CO₂）的吞吐效果，分析了作用机理。实验结果表明：注气吞吐提高采收率效果显著，最低换油率的N₂吞吐也能达到0.422；CO₂与N₂混合气吞吐中，CO₂溶于原油中能使其黏度降低，N₂由于重力分异作用占据缝洞高部位形成气顶，这种协同作用使得CO₂与N₂混合气吞吐效果好于单一注气吞吐；而在注气顺序上先注N₂后注CO₂吞吐效果更加明显，换油率可达0.861。缝洞型油藏注气吞吐开采是一种行之有效提高采收率的方法，先注N₂后注CO₂混合气吞吐可获得更显著的开发效果。

关键词: 缝洞型稠油油藏, 注气吞吐, 吞吐物理模型, 二氧化碳, 氮气, 提高采收率

Abstract: Large water-eroded caves, solution pores, and fractures are the main spaces of fractured vuggy carbonate reservoirs with strong heterogeneity. The technology of gas huff-n-puff is an effective way to improve oil recovery in such reservoirs. In this study, an indoor physical simulation apparatus was designed and produced for carbonate reservoirs in order to explore the huff-n-puff effect of different gases. The huff-n-puff effect and its mechanism for four gases(CO₂, N₂, CO₂ injected before N₂, CO₂ injected after N₂) were analyzed considering the parameters of oil change rate, gas generation rate, and cumulative gas production. The experimental results show that the huff-n-puff mechanism of the four injected gases is obvious. The lowest oil change rate was 0.422(N₂ huff-n-puff). The mixed gas (CO₂ and N₂ mixture) huff-n-puff fully develops a synergistic effect. CO₂ dissolved in crude oil decreases oil viscosity, while N₂ occupies the high positions of caves and forms a gas cap due to gravitational differentiation. The huff-n-puff effect of the gaseous mixture of CO₂ and N₂ is better than that of a single gas, and CO₂ injection after N₂ huff-n-puff can achieve the best effect with an oil change rate of 0.861. Experimental research shows that gas huff-n-puff is an effective EOR, and the huff-n-puff effect of CO₂ injected after N₂ is more remarkable.

Key words: fractured-vuggy heavy oil reservoir, gas injection huff-n-puff, huff-n-puff physical simulation, CO₂, N₂, enhanced oil recovery

中图分类号:

TE327

苏伟, 侯吉瑞, 刘娟, 朱道义, 席园园. 缝洞型碳酸盐岩油藏注气吞吐EOR效果评价[J]. 西南石油大学学报(自然科学版), 2017, 39(1): 133-139.

SU Wei, HOU Jirui, LIU Juan, ZHU Daoyi, XI Yuanyuan. Evaluation of EOR Effect of Gas Huff-n-puff in Fractured Vuggy Carbonate Reservoirs[J]. 西南石油大学学报(自然科学版), 2017, 39(1): 133-139.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal15.magtechjournal.com/Jwk_xnzk/CN/10.11885/j.issn.1674-5086.2015.04.24.01

http://journal15.magtechjournal.com/Jwk_xnzk/CN/Y2017/V39/I1/133

参考文献

[1] 陈志海,戴勇,郎兆新. 缝洞性碳酸盐岩油藏储渗模式及其开采特征[J]. 石油勘探与开发, 2005, 32(3):101-105. doi:10.3321/j.issn:1000-0747.2005.03.025 CHEN Zhihai, DAI Yong, LANG Zhaoxin. Storagepercolation modes and production performance of the karst reservoirs in Tahe Oilfield[J]. Petroleum Exploration and Development, 2005, 32(3):101-105. doi:10.3321/j.issn:1000-0747.2005.03.025
[2] 刘中春. 塔河油田缝洞型碳酸盐岩油藏提高采收率技术途径[J]. 油气地质与采收率, 2012, 19(6):66-68, 86. doi:10.3969/j.issn.1009-9603.2012.06.016 LIU Zhongchun. Enhanced oil recovery in Tahe karstic/fractured carbonate reservoir[J]. Petroleum Geology and Recovery Efficiency, 2012, 19(6):66-68, 86. doi:10.3969/j.issn.1009-9603.2012.06.016
[3] 康志江,李江龙,张冬丽,等. 塔河缝洞型碳酸盐岩油藏渗流特征[J]. 石油与天然气地质, 2005, 26(5):634-640, 673. doi:10.11743/ogg20050513 KANG Zhijiang, LI Jianglong, ZHANG Dongli, et al. Percolation characteristics of fractured-vuggy carbonate reservoir in Tahe Oilfield[J]. Oil & Gas Geology, 2005, 26(5):634-640, 673. doi:10.11743/ogg20050513
[4] 张希明. 新疆塔河油田下奥陶统碳酸盐岩缝洞型油气藏特征[J]. 石油勘探与开发, 2001, 28(5):17-22. doi:10.3321/j.issn:1000-0747.2001.05.005 ZHANG Ximing. The characteristics of Lower Ordovician fissure-vug carbonate oil and gas pools in Tahe Oilfield, Xinjiang[J]. Petroleum Exploration and Development, 2001, 28(5):17-22. doi:10.3321/j.issn:1000-0747.2001.05.005
[5] 李阳. 塔河油田碳酸盐岩缝洞型油藏开发理论及方法[J]. 石油学报, 2013, 34(1):115-121. doi:10.7623/syxb201301013 LI Yang. The theory and method for development of carbonate fractured-cavity reservoirs in Tahe Oilfield[J]. Acta Petrolei Sinica, 2013, 34(1):115-121. doi:10.7623/syxb201301013
[6] 邬光辉,刘虎,石晓龙. 塔里木盆地下古生界海相碳酸盐岩油气的特殊性[J]. 海相油气地质, 2014, 19(3):1-7. doi:10.3969/j.issn.1672-9854.2014.03.001 WU Guanghui, LIU Hu, SHI Xiaolong. Particularities of hydrocarbon in Lower Paleozoic Marine Carbonate rocks in Tarim Basin[J]. Marine Origin Petroleum Geology, 2014, 19(3):1-7. doi:10.3969/j.issn.1672-9854.2014.03.001
[7] 赵文革. 塔河油田碳酸盐岩缝洞油藏油水关系研究[D]. 成都:成都理工大学, 2006. ZHAO Wenge. Study on oil-water relationship of carbonate fracture-cavity reservoir in Tahe Oilfield[D]. Chengdu:Chengdu University of Technology, 2006.
[8] 杨坚,吴涛. 塔河油田碳酸盐岩缝洞型油气藏开发技术研究[J]. 石油天然气学报, 2008, 30(3):326-328. YANG Jian, WU Tao. Technique of reservoir development in carbonate fracture-vug reservoirs in Tahe Oilfield[J]. Journal of Oil and Gas Technology, 2008, 30(3):326-328.
[9] 蔡秀玲,周正平,杜风华. CO₂单井吞吐技术的增油机理及应用[J]. 石油钻采工艺, 2002, 24(4):45-46. doi:10.3969/j.issn.1000-7393.2002.04.014 CAI Xiuling, ZHOU Zhengping, DU Fenghua. Increase production mechanism and application of CO₂ huff and puff technology[J]. Oil Drilling & Production Technology, 2002, 24(4):45-46. doi:10.3969/j.issn.1000-7393.2002.04.014
[10] DAVIS T L, BENSON R D, ROCHE S L, et al. Dynamic reservoir characterization of a CO₂ huff ‘n’ puff, central vacuum unit, lea county, New Mexico[C]. SPE 38694, 1997. doi:10.2118/38694-MS
[11] BAKSHI A K, OGBE D O, KAMATH V A, et al. Feasibility study of CO₂ stimulation in the West Sak Field, Alaska[C]. SPE 24038, 1992. doi:10.2118/24038-MS
[12] 李相远,李向良,郭平,等. 低渗透稀油油藏二氧化碳吞吐选井标准研究[J]. 油气地质与采收率,2001,8(5):66-68. doi:10.3969/j.issn.1009-9603.2001.05.019 LI Xiangyuan, LI Xiangliang, GUO Ping, et al. Study on well selection criterion of CO₂ stimulation in thin oil reservoirs with low permeability[J]. Petroleum Geology and Recovery Efficiency, 2001, 8(5):66-68. doi:10.3969/j.issn.1009-9603.2001.05.019
[13] 刘鹏飞,姜汉桥,徐晖,等. 缝洞型油藏开发室内模拟研究[J]. 石油钻采工艺, 2009, 31(5):72-76. doi:10.3969/j.issn.1000-7393.2009.05.018 LIU Pengfei, JIANG Hanqiao, XU Hui, et al. Laboratory simulation study on exploitation of fractured and cavernous reservoirs[J]. Oil Drilling & Production Technology, 2009, 31(5):72-76. doi:10.3969/j.issn.1000-7393.2009.05.018
[14] 郭秀东,赵海洋,胡国亮,等. 缝洞型油藏超深井注氮气提高采收率技术[J]. 石油钻采工艺, 2013, 35(6):98-101. GUO Xiudong, ZHAO Haiyang, HU Guoliang, et al. Ultra-deep wells in fractured-vuggy reservoir nitrogen injection EOR technology[J]. Oil Drilling & Production Technology, 2013, 35(6):98-101.
[15] 惠健,刘学利,汪洋,等. 塔河油田缝洞型油藏注气替油机理研究[J]. 钻采工艺, 2013, 36(2):55-57. doi:10.3969/J.ISSN.1006-768X.2013.02.16 HUI Jian, LIU Xueli, WANG Yang, et al. Mechanism research on gas injection to displace the oil remaining in fractured-vuggy reservoirs of Tahe Oilfield[J]. Drilling & Production Technology, 2013, 36(2):55-57. doi:10.3969/J.ISSN.1006-768X.2013.02.16
[16] 陈琳,康志宏,李鹏,等. 塔河油田奥陶系岩溶型碳酸盐岩油藏储集空间发育特征及地质模式探讨[J]. 现代地质, 2013, 27(2):356-365. doi:10.3969/j.issn.1000-8527.2013.02.014 CHEN Lin, KANG Zhihong, LI Peng, et al. Development characteristics and geological model of Ordovician karst carbonate reservoir space in Tahe Oilfield[J]. Geoscience, 2013, 27(2):356-365. doi:10.3969/j.issn.1000-8527.2013.02.014
[17] 荣元帅,赵金洲,鲁新便,等. 碳酸盐岩缝洞型油藏剩余油分布模式及挖潜对策[J]. 石油学报, 2014, 35(6):1138-1146. doi:10.7623/syxb201406011 RONG Yuanshuai, ZHAO Jinzhou, LU Xinbian, et al. Remaining oil distribution patterns and potential-tapping countermeasures in carbonate fracture-cavity reservoir[J]. Acta Petrolei Sinica, 2014, 35(6):1138-1146. doi:10.7623/syxb201406011
[18] 李生青,廖志勇,杨迎春. 塔河油田奥陶系碳酸盐岩油藏缝洞单元注水开发分析[J]. 新疆石油天然气, 2011,7(2):40-44. doi:10.3969/j.issn.1673-2677.2011.02.010 LI Shengqing, LIAO Zhiyong, YANG Yingchun. A discussion on water flooding in the multi-well fracturedvuggy units of carbonate reservoirs in Tahe Oilfield[J]. Xinjiang Oil & Gas, 2011, 7(2):40-44. doi:10.3969/j.issn.1673-2677.2011.02.010
[19] 侯吉瑞,李海波,姜瑜,等. 多井缝洞单元水驱见水模式宏观三维物理模拟[J]. 石油勘探与开发, 2014, 41(6):717-722. doi:10.11698/PED.2014.06.10 HOU Jirui, LI Haibo, JIANG Yu, et al. Macroscopic three-dimensional physical simulation of water flooding in multi-well fracture-cavity unit[J]. Petroleum Exploration and Development, 2014, 41(6):717-722. doi:10.11698/PED.2014.06.10
[20] 陈青,王大成,闫长辉,等. 碳酸盐岩缝洞型油藏产水机理及控水措施研究[J]. 西南石油大学学报(自然科学版),2011, 33(1):125-130. doi:10.3863/j.issn.1674-5086.2011.01.022 CHEN Qing, WANG Dacheng, YAN Changhui, et al. Research on water producing mechanism and water controlling measures for fracture-cave type carbonate reservoir[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2011, 33(1):125-130. doi:10.3863/j.issn.1674-5086.2011.01.022
[21] 李宗宇. 塔河奥陶系缝洞型碳酸盐岩油藏开发对策探讨[J]. 石油与天然气地质, 2007, 28(6):856-862. doi:10.3321/j.issn:0253-9985.2007.06.023 LI Zongyu. A discussion on development strategies for the Ordovician fractured-vuggy carbonate rock reservoirs in Tahe Oilfield[J]. Oil & Gas Geology, 2007, 28(6):856-862. doi:10.3321/j.issn:0253-9985.2007.06.023
[22] 任玉林,李江龙,黄孝特. 塔河油田碳酸盐岩油藏开发技术政策研究[J]. 油气地质与采收率, 2004, 11(5):57-59. doi:10.3969/j.issn.1009-9603.2004.05.020 REN Yulin, LI Jianglong, HUANG Xiaote. Study on developmental technologic strategies in Tahe carbonate Oilfield[J]. Petroleum Geology and Recovery Efficiency, 2004, 11(5):57-59. doi:10.3969/j.issn.1009-9603.2004.05.020
[23] 李海波,侯吉瑞,李巍,等. 碳酸盐岩缝洞型油藏氮气泡沫驱提高采收率机理可视化研究[J]. 油气地质与采收率, 2014, 21(4):93-96, 106. doi:10.3969/j.issn.1009-9603.2014.04.022 LI Haibo, HOU Jirui, LI Wei, et al. Laboratory research on nitrogen foam injection in fracture-vuggy reservoir for enhanced oil recovery[J]. Petroleum Geology and Recovery Efficiency, 2014, 21(4):93-96, 106. doi:10.3969/j.issn.1009-9603.2014.04.022
[24] 胡蓉蓉,姚军,孙致学,等. 塔河油田缝洞型碳酸盐岩油藏注气驱油提高采收率机理研究[J]. 西安石油大学学报(自然科学版), 2015, 30(2):49-53, 59. doi:10.3969/j.issn.1673-064X.2015.02.009 HU Rongrong, YAO Jun, SUN Zhixue, et al. Study on EOR mechanism by gas injection replacing oil in fracturedvuggy carbonate reservoir of Tahe Oilfield[J]. Journal of Xi'an Shiyou University(Natural Science Edition), 2015, 30(2):49-53, 59. doi:10.3969/j.issn.1673-064X.2015.02.009

缝洞型碳酸盐岩油藏注气吞吐EOR效果评价

Evaluation of EOR Effect of Gas Huff-n-puff in Fractured Vuggy Carbonate Reservoirs

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋传真, 朱桂良, 刘中春. 缝洞型油藏氮气扩散系数测定及影响因素[J]. 西南石油大学学报(自然科学版), 2020, 42(4): 95-103.
[2]	张德平, 马锋, 吴雨乐, 董泽华. 用于CO₂注气驱的油井缓蚀剂加注工艺优化研究[J]. 西南石油大学学报(自然科学版), 2020, 42(2): 103-109.
[3]	王有智. 珲春盆地八连城矿区煤岩孔隙分形特征[J]. 西南石油大学学报(自然科学版), 2020, 42(1): 57-68.
[4]	李永太, 孔柏岭. 提高三元复合驱现场应用效果的技术途径[J]. 西南石油大学学报(自然科学版), 2019, 41(4): 113-119.
[5]	张智, 宋闯, 窦雪锋, 杨昆, 丁剑. CO₂吞吐井套管腐蚀规律及极限吞吐轮次研究[J]. 西南石油大学学报(自然科学版), 2019, 41(4): 135-143.
[6]	梁萌, 袁海云, 杨英, 杨云博, 蔺江涛. 气体混相驱与最小混相压力测定研究进展[J]. 西南石油大学学报(自然科学版), 2017, 39(5): 101-112.
[7]	朱文卿, 常宝华, 熊伟, 高树生. 裂缝-孔洞储层连通溶洞模式注气效果研究[J]. 西南石油大学学报(自然科学版), 2017, 39(1): 100-106.
[8]	刘学利, 胡文革, 谭涛, 张林艳, 刘蕊. 塔河底水砂岩油藏氮气泡沫驱技术研究[J]. 西南石油大学学报(自然科学版), 2016, 38(6): 105-110.
[9]	何胜林1，赵军2 *，周家雄1，张海荣1，王迪2. 天然气藏中二氧化碳含量的测井定量评价方法[J]. 西南石油大学学报(自然科学版), 2016, 38(4): 82-88.
[10]	郭日鑫*. 热自生CO2 吞吐中技术研究及其应用[J]. 西南石油大学学报(自然科学版), 2015, 37(5): 139-144.
[11]	刘祖鹏1 *，李兆敏2. CO2 驱油泡沫防气窜技术实验研究[J]. 西南石油大学学报(自然科学版), 2015, 37(5): 117-122.
[12]	刘永辉1 *，罗程程1，张烈辉1，王峰2，辛涛云2. 分层注CO2 井系统模型研究[J]. 西南石油大学学报(自然科学版), 2015, 37(5): 123-127.
[13]	吴剑1，2 *，常毓文1，李嘉1，梁涛1，郭晓飞1. 低矿化度水驱技术增产机理与适用条件[J]. 西南石油大学学报(自然科学版), 2015, 37(5): 145-151.
[14]	冯其红1，王波2 *，王相1，王守磊3，韩晓冬4. 基于油藏流场强度的井网优化方法研究[J]. 西南石油大学学报(自然科学版), 2015, 37(4): 181-186.
[15]	谢晓庆1，2 *，冯国智1，2，刘立伟1，2，石爻1，2，曾杨1，2. 聚驱后残留聚合物分布及对二元驱的增效作用[J]. 西南石油大学学报(自然科学版), 2015, 37(4): 135-140.