Application and Research of Hot Self-generated CO2 Technology in#br#
Steam Soaking

doi:10.11885/j.issn.1674-5086.2013.12.04.01

Abstract

Abstract:

Hot self-generated CO2 technology is focused on the problems of recovery difficulty，poor effect of steam soaking
and so on for heavy oil reservoirs. This technology combines steam flooding and gas flooding and improves the effect of steam
soaking in heavy oil reservoir. Its main mechanism is the application of steam to heat blowing agent and generate a large volume
of gases（including CO2，NH3，etc）in the formation. Some of these gases react with the oil to reduce the oil viscosity，others
form miscible flooding to reduce water interfacial tension，so as to enhance oil recovery. An optimized selection of the heat
blowing agents was performed. By comparing the difference of blowing agent solution before and after the reaction，we find
that alkaline increases after the reaction（pH changes in value from 8.26 to 9.71~10.02），which is helpful to reduce oil viscosity
and lower interfacial tension，etc. Studies indicate that Heat-generating CO2 flooding technology can get a maximum viscosity
reduction rate of 76.7%；oil-water interfacial tension decreases by 54.77%，and further improve oil recovery by 4.18% in the
5th steam soaking. Single cycle input-output ratio averages 1.0：3.2，which shows a technical advantage toward conventional
EOR method and a preferable economic profit. The field experiments found that the technique can greatly improve the oil
production，which will provide a powerful technical supporting for the efficient development of heavy oil.

Key words: hot self-generated CO2 technology, heavy oil, steam soaking, viscosity reduction rate, EOR

CLC Number:

TE357.4

Guo Rixin*. Application and Research of Hot Self-generated CO2 Technology in#br# Steam Soaking[J]. 西南石油大学学报(自然科学版), DOI: 10.11885/j.issn.1674-5086.2013.12.04.01.

0
/ / Recommend

Add to citation manager EndNote|Ris|BibTeX

URL: http://journal15.magtechjournal.com/Jwk_xnzk/EN/10.11885/j.issn.1674-5086.2013.12.04.01

http://journal15.magtechjournal.com/Jwk_xnzk/EN/Y2015/V37/I5/139

References

[1] 张锐，薄启亮，刘尚奇，等. 稠油开采的前沿技术[J]. 世
界石油工业，1998，5（9）：29 35.
[2] 唐纪云. 注水开发稠油油藏氮气泡沫调驱技术[J]. 石油
钻采工艺，2009，31（5）：93 96.
Tang Jiyun. Nitrogen foam profile control in waterflooding
heavy oil reservoir[J]. Oil Drilling & Production Technology，
2009，31（5）：93 96.
[3] 周守为，孙福街，曾祥林，等. 稠油油藏分支水平井适
度出砂开发技术[J]. 石油勘探与开发，2008，35（5）：
630 635.
Zhou Shouwei，Sun Fujie，Zeng Xianglin，et al. Application
of multilateral wells with limited sand production to
heavy oil reservoirs[J]. Petroleum Exploration and Development，
2008，35（5）：630 635.
[4] 王伟伟. 同心管注汽技术在超稠油开发中的研究与应
用[J]. 内蒙古石油化工，2009（24）：126 128.
[5] 吴向红，许安著，范海亮. 稠油油藏过热蒸汽吞吐开
采效果综合评价[J]. 石油勘探与开发，2010，37（5）：
608 613.
Wu Xianghong，Xu Anzhu，Fan Hailiang. An integrated
evaluation on factors affecting the performance of superheated
steam huff and puff in heavy oil reservoirs[J].
Petroleum Exploration and Development，2010，37（5）：
608 613.
[6] 黄伟强，王利华，陈忠强，等. 复合蒸汽吞吐提高稠油
采收率试验[J]. 新疆石油地质，2010，31（1）：69 71.
Huang Weiqiang，Wang Lihua，Chen Zhongqiang，et al.
Experiment for improving heavy oil recovery by combination
steam stimulation process[J]. Xinjiang Petroleum
Geology，2010，31（1）：69 71.
[7] 李孟涛，单文文，刘先贵，等. 超临界二氧化碳混相驱
油机理实验研究[J]. 石油学报，2006，27（3）：80 83.
Li Mengtao，Shan Wenwen，Liu Xiangui，et al. Laboratory
study on miscible oil displacement mechanism of supercritical
carbon dioxide[J]. Acta Petrolei Sinica，2006，
27（3）：80 83.
[8] 李孟涛，张浩，刘先贵，等. CO2 驱化学机理实验研
究[J]. 化学与生物工程，2005（9）：7 9，27.
Li Mengtao，Zhang Hao，Liu Xiangui，et al. Laboratory
studies of chemical mechanisms on the CO2 oildisplacing[
J]. Chemistry & Bioengineering，2005（9）：
7 9，27.
[9] 范洪富. 辽河稠油水热裂解反应研究与应用[D]. 大庆：
大庆石油学院，2002.
[10] Picha M S. Enhanced oil recovery by hot CO2 flooding[C].
SPE 105425，2007.
[11] 杜殿发，郭青，侯加根. 稠油油藏蒸汽吞吐筛选标准的
探讨[J]. 新疆石油地质，2010，31（4）：440 443.
Du Dianfa，Guo Qing，Hou Jiagen. Discussion on screening
conditions for steam huff and puff in super heavy oil
reservoirs[J]. Xinjiang Petroleum Geology，2010，31（4）：
440 443.

[1]	ZHANG Lijun, WANG Shuai, ZHENG Wei. Establishment of a New Method for Viscosity Calculation of Crude Oil by Data Analysis [J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2020, 42(6): 49-55.
[2]	LI Zhi, ZHANG Zhiye, HE Dengfa, LUO Xi, XIONG Jian. 3D Geometrical and Kinematic Characteristics of the Boundary Fault in Nanyang Depression [J]. 西南石油大学学报(自然科学版), 2020, 42(5): 48-62.
[3]	DUAN Yonggang, WU Zijian, WEI Mingqiang, REN Keyi, LU Chuan. Influence of EBIP Thickness Variation Modes on SAGD Production Characteristics in Super Heavy Oil Reservoirs [J]. 西南石油大学学报(自然科学版), 2020, 42(5): 127-134.
[4]	ZHANG Jilei, LUO Xianbo, HE Yifan, OUYANG Yuwei, XU Ya'nan. Influence of Time-varying Reservoir Physical Properties on Water Cone Change of Directional Wells in Heavy Oil and Bottom Water Reservoirs [J]. 西南石油大学学报(自然科学版), 2020, 42(2): 133-140.
[5]	WANG Yanwei, LIU Huiqing, DONG Xiaohu, ZHANG Qichen. Physical Simulation of Cold Recovery of Edge Water Heavy Oil Reservoir After Steam Stimulation [J]. 西南石油大学学报(自然科学版), 2020, 42(1): 91-100.
[6]	LUO Chuan, ZHOU Penggao, YANG Hu, SHI Jiangang. Stress Sensitivity Characteristics of Low Permeability Reservoirs [J]. 西南石油大学学报(自然科学版), 2020, 42(1): 119-125.
[7]	LI Peng, FAN Qianqian, HUO Minghui, ZHENG Lanian, YUE Jun. Researches on Relationship Between Production Allocation and Decline Rate of Gas Wells in Sulige Gas Field [J]. 西南石油大学学报(自然科学版), 2020, 42(1): 126-132.
[8]	LIAN Zhanghua, ZHANG Jin, WANG Yuhai, ZHANG Qiang, LIU Yonggang. Theoretical Research on Circumferential Stress of Four-point Bending Specimen of Unequal Thickness [J]. 西南石油大学学报(自然科学版), 2020, 42(1): 161-169.
[9]	GUO Xiao, YANG Kairui, YANG Yurui, JIA Haowei. Influence of Seepage Velocity on Shale Gas Exploration by Pore Network Simulation [J]. 西南石油大学学报(自然科学版), 2019, 41(6): 19-27.
[10]	ZHAO Jun, LIU Kai, YANG Lin, HE Yufei. Calculation Model of Shale Gas Adsorption Capacity Under Supercritical Conditions [J]. 西南石油大学学报(自然科学版), 2019, 41(5): 127-133.
[11]	LIAN Zhanghua, LIANG Jiankun, WANG Yuhai, ZHANG Qiang, MOU Yisheng. Equation Derivation and Verification for Hoop Stress and Load of C-ring [J]. 西南石油大学学报(自然科学版), 2019, 41(5): 161-168.
[12]	ZHENG Wei, ZHU Guojin, TAN Xianhong, LIU Xinguang, WANG Lei. Experimental Study on Physical Simulation of In-situ Combustion in Offshore Heavy Oilfields [J]. 西南石油大学学报(自然科学版), 2019, 41(4): 107-112.
[13]	MA Qiang, LIN Riyi, HAN Chaojie, YUAN Gaoliang, YU Wanmin. An Experimental Investigation of H₂S Production by Thermochemical Sulfate Reduction in Heavy Oil [J]. 西南石油大学学报(自然科学版), 2019, 41(4): 175-182.
[14]	WANG Zhichen, LÜ Zhenhu, DONG Jingfeng, ZHANG Fengjuan, ZHOU Peiyao. Influence of Multivalent Metal Ions on Organic Borate-crosslinked Guanidine Gum Fracturing Gluids: Analysis and Countermeasures [J]. 西南石油大学学报(自然科学版), 2019, 41(3): 177-184.
[15]	FENG Gaocheng, HU Yunpeng, YAO Weiying, ZHANG Yu, YUAN Zhe. Development and Application of Gas Injection for Oil Recovery from Offshore Oilfields [J]. 西南石油大学学报(自然科学版), 2019, 41(1): 147-155.

Application and Research of Hot Self-generated CO2 Technology in#br# Steam Soaking

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments