基于有限元的南缘高泉试验水平井稳定性评价

doi:10.11885/j.issn.1674-5086.2020.10.29.01

摘要/Abstract

摘要： 南缘高泉背斜清水河组储层具有三高一深（即高温、高压、高产和超深）特征，国内尚无成熟完井案例可循。为优选合适的完井方式，针对目标区试验水平井分别建立了预孔筛管完井、套管射孔完井的井筒和地层的稳定性模型，对其全生命周期井壁稳定性开展了数值模拟研究。结果表明，当井筒沿着最小水平主应力方向时，孔眼应力集中在平行于最小水平主应力方向最大，在垂直于最小水平主应力方向最小，井筒的破坏会从外壁孔眼处开始；筛管和套管只会产生部分塑性变形，变形量小于5%，发生挤毁可能性不大，但生产后期筛管完井地层必定会发生坍塌，固井后的射孔地层相对比较稳定，从井壁稳定性出发对目标区此类三高一深特征水平井可优先推荐采用射孔进行完井。

关键词: 水平井, 三高一深, 完井, 井壁稳定, 生产压差

Abstract: Qingshuihe Formation reservoir in Gaoquan Anticline in the south margin has the characteristics of high temperature, high pressure, high yield and ultra deepth. There is no mature completion case to follow in China. In this paper, the wellbore and formation stability models of pre perforated screen completion and casing perforation completion are established respectively for horizontal wells in target area, and numerical simulation study on wellbore stability in whole life cycle is carried out for opital completion mode. The results show that when the wellbore is along the direction of the minimum horizontal principal stress, the hole stress concentration is the maximum parallel to the minimum horizontal principal stress direction, and is the minimum perpendicular to the minimum horizontal principal stress direction, and the wellbore damage will start from the outer wall hole; the screen pipe and casing will only produce partial plastic deformation, with the deformation less than 5%, and small possibility of collapse, but the formation which screen tube completion is bound to collapse in the late production stage, and the perforated formation after cementing is relatively stable. Based on the wellbore stability, perforation can be preferentially recommended for such horizontal wells with similar characteristics in the target area.

Key words: horizontal well, three high and one deep, completion, wellbore stability, producing pressure

中图分类号:

TE257

刘涛, 刘飞航, 马都都, 郭玲, 吴越. 基于有限元的南缘高泉试验水平井稳定性评价[J]. 西南石油大学学报(自然科学版), 2022, 44(4): 91-99.

LIU Tao, LIU Feihang, MA Dudu, GUO Ling, WU Yue. Stability Evaluation of Gaoquan Test Horizontal Well in Southern Margin Based on Finite Element Method[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2022, 44(4): 91-99.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal15.magtechjournal.com/Jwk_xnzk/CN/10.11885/j.issn.1674-5086.2020.10.29.01

http://journal15.magtechjournal.com/Jwk_xnzk/CN/Y2022/V44/I4/91

参考文献

[1] 丁振龙, 刘绘新.有限元法在油气井井壁稳定计算中的应用[J].钻采工艺, 2006, 29(2):23-24, 27. doi:10.3969/j.issn.1006-768X.2006.02.008 DING Zhenlong, LIU Huixin. Application of the finite element method in calculating sidewell stability[J]. Drilling and Production Technology, 2006, 29(2):23-24, 27. doi:10.3969/j.issn.1006-768X.2006.02.008
[2] 鄢荣, 刘洪.有限元方法与解析计算在分析水平井井壁稳定问题中的运用[J].内蒙古石油化工, 2010, 36(5):126-127. doi:10.3969/j.issn.1006-7981.2010.05.069 YAN Rong, LIU Hong. The application of finite element method and analysis calculation in studying the wellbore stability[J]. Inner Mongolia Petrochemical, 2010, 36(5):126-127. doi:10.3969/j.issn.1006-7981.2010.05.069
[3] 肖伟, 吴晓东, 韩国庆, 等.用突变理论综合评价法优选完井方式[J].石油钻采工艺, 2008, 30(6):46-51. doi:10.3969/j.issn.1000-7393.2008.06.011 XIAO Wei, WU Xiaodong, HAN Guoqing, et al. Well completion system optimum selection by catastrophe theory comprehensive evaluating method[J]. Petroleum Drilling and Production Technology, 2008, 30(6):46-51. doi:10.3969/j.issn.1000-7393.2008.06.011
[4] AL-AJMI A M A S, ZIMMERMAN R W. A new well path optimization model for increased mechanical borehole stability[J]. Journal of Petroleum Science and Engineering, 2009(1-2):53-62.
[5] BARREE R D, COX S A, MISKIMINS J L, et al. Economic optimization of horizontal-well completions in unconventional reservoirs[J]. SPE Production & Operations, 2015(4):293-311.
[6] 张玉梅.台H5-1水平井钻井完井工艺技术[J].天然气地球科学, 2009, 20(4):631-635. ZHANG Yumei. Horizontal drilling and completion techniques for Well Tai H5-1[J]. Natural Gas Geoscience, 2009, 20(4):631-635.
[7] 刘明球, 周天鹏, 敬祖佑, 等.高压高产气田完井采气工艺技术研究——以克拉2气田开采配套工艺技术的推荐方案为例[J].天然气地球科学, 2003, 14(2):140-144. doi:10.3969/j.issn.1672-1926.2003.02.012 LIU Mingqiu, ZHOU Tianpeng, JING Zuyou, et al. Study on technology of well completion and gas recovery in high pressure and high yield gas field:Example for performance technology of gas recovery design recommended for Kela 2 Gas Field[J]. Natural Gas Geoscience, 2003, 14(2):140-144. doi:10.3969/j.issn.1672-1926.2003.02.012
[8] 冯哲.伊拉克M油田水平井完井工艺优化[J].海洋石油, 2019, 39(4):65-68. doi:10.3969/j.issn.1008-2336.2019.04.065 FENG Zhe. Horizontal well completion technology optimization of M Oilfield in Iraq[J]. Offshore Oil, 2019, 39(4):65-68. doi:10.3969/j.issn.1008-2336.2019.04.065
[9] 董锎云.元坝超深水平井完井方式适应性评价及优选[D].成都:西南石油大学, 2015. DONG Kanyun. Adaptability evaluation and optimization of completion methods for Yuanba ultra deep horizontal wells[D]. Chengdu:Southwest Petroleum University, 2015.
[10] 段春兰.川东北元坝地区陆相地层井壁稳定技术研究[D].成都:西南石油大学, 2015. DUAN Chunlan. Research on wellbore stability technology of continental strata in Yuanba Area, Northeast Sichuan[D]. Chengdu:Southwest Petroleum University, 2015.
[11] 费康, 张建伟. ABAQUS在岩土工程中的应用[M].北京:中国水利水电出版社, 2010. FEI Kang, ZHANG Jianwei. Application of ABAQUS in geotechnical engineering[M]. Beijing:China Water Resources and Hydropower Press, 2010.
[12] 张文波, 周鹏高, 李亚双, 等.不同地应力场对大斜度井井壁稳定规律的影响[J].天然气技术, 2010, 4(1):58-60. ZHANG Wenbo, ZHOU Penggao, LI Yashuang, et al. Effect of borehole stability in highly deviated wells under different in-situ stress fields[J]. Natural Gas Technology, 2010, 4(1):58-60.
[13] 兰凯, 熊友明, 闫光庆, 等.川东北水平井储层井壁稳定性及其对完井方式的影响[J].吉林大学学报(地球科学版), 2011, 41(4):1233-1238. doi:10.3969/j.issn.1671-5888.2011.04.039 LAN Kai, XIONG Youming, YAN Guangqing, et al. Horizontal borehole stability and its influence on well completion optimization in the Northeast Sichuan Basin[J]. Journal of Jilin University(Earth Science Edition), 2011, 41(4):1233-1238.doi:10.3969/j.issn.1671-5888.2011.04.039
[14] 胡成军, 陈强, 张鹏, 等.渤海油田中深部地层井壁稳定对策[J].石油钻采工艺, 2018, 40(z1):94-97. doi:10.13639/j.odpt.2018.S0.026 HU Chengjun, CHEN Qiang, ZHANG Peng, et al. Countermeasures for the borehole stability in middle and deep strata of Bohai Oilfield[J]. Petroleum Drilling and Production Technology, 2018, 40(z1):94-97. doi:10.13639/j.odpt.2018.S0.026
[15] 邹灵战, 汪海阁, 张红军, 等.大港滩海大位移井井壁稳定技术研究[J].重庆科技学院学报(自然科学版), 2012, 14(5):80-82. doi:10.3969/j.issn.1673-1980.2012.05.020 ZOU Lingzhan, WANG Haige, ZHANG Hongjun, et al. The bore-hole stability technique in Dagang Nearshore Oilfield[J]. Journal of Chongqing University of Science and Technology(Natural Sciences Edition), 2012, 14(5):80-82. doi:10.3969/j.issn.1673-1980.2012.05.020
[16] 柳青.地应力类型影响定向井井壁稳定的规律分析[J].文摘版(工程技术), 2016(3):260. LIU Qing. Analysis on the law of in-situ stress type affecting wellbore stability of directional wells[J]. Abstract Edition(Engineering Technology), 2016(3):260.
[17] 王翔.鄂尔多斯盆地西部页岩油水平井井壁稳定技术[J].石油地质与工程, 2019, 33(4):88-91. doi:10.3969/j.issn.1673-8217.2019.04.022 WANG Xiang. Wellbore stability technique in horizontal wells for shale oil reservoirs in Western Ordos Basin[J]. Petroleum Geology and Engineering, 2019, 33(4):88-91. doi:10.3969/j.issn.1673-8217.2019.04.022
[18] 张海洋.水平井完井方式优选及参数设计方法与应用[D].北京:中国石油大学, 2018. ZHANG Haiyang. Optimization of horizontal well completion mode and parameter design method and application[D]. Beijing:China University of Petroleum, 2018.
[19] 胡长明, 袁一力, 梅源, 等.基于ABAQUS的地层-结构法模型的地应力平衡方法研究[J].现代隧道技术, 2018, 55(4):76-86. doi:10.13807/j.cnki.mtt.2018.04.012 HU Changming, YUAN Yili, MEI Yuan, et al. Initial geo-stress balance method for the finite-element model using the stratum-structure method[J]. Modern Tunnel Technology, 2018, 55(4):76-86. doi:10.13807/j.cnki.mtt.2018.04.012
[20] 鄢荣, 刘洪.有限元方法与解析计算在分析水平井井壁稳定问题中的运用[J].内蒙古石油化工, 2010, 36(5):126-127. doi:10.3969/j.issn.1006-7981.2010.05.069 YAN Rong, LIU Hong. Application of finite element method and analytical calculation in the analysis of wellbore stability of horizontal wells[J]. Inner Mongolia Petrochemical, 2010, 36(5):126-127. doi:10.3969/j.issn.1006-7981.2010.05.069
[21] 张丹丹, 冯雨实, 李永臣, 等.基于有限元软件的煤层气水平井井壁稳定数值模拟[J].煤矿安全, 2018, 49(3):144-147. doi:10.13347/j.cnki.mkaq.2018.03.039 ZHANG Dandan, FENG Yushi, LI Yongchen, et al. Numerical simulation of wellbore stability for CBM horizontal well by finite element software[J]. Coal Mine Safety, 2018, 49(3):144-147.doi:10.13347/j.cnki.mkaq.2018.03.039
[22] 代汝林, 李忠芳, 王姣.基于ABAQUS的初始地应力平衡方法研究[J].重庆工商大学学报(自然科学版), 2012, 29(9):76-81. doi:10.3969/j.issn.01672-058X.2012.09.016 DAI Rulin, LI Zhongfang, WANG Jiao. Research on initial geo-stress balance method based on ABAQUS[J]. Journal of Chongqing Technology and Business University(Natural Science Edition), 2012, 29(9):76-81. doi:10.3969/j.issn.1672-058X.2012.09.016
[23] 曹金凤, 石亦平. ABAQUS有限元分析常见问题解答[M].北京:机械工业出版社, 2009. CAO Jinfeng, SHI Yiping. ABAQUS finite element analysis FAQ[M]. Beijing:China Machine Press, 2009.
[24] 蒋玉川, 张建海.弹性力学简明教程[M].北京:化学工业出版社, 2020. JIANG Yuchuan, ZHANG Jianhai. A concise course of elasticity[M]. Beijing:Chemical Industry Press, 2020.
[25] 宋少云, 尹芳.有限元网格划分中的圣维南原理及其应用[J].机械设计与制造, 2012(8):63-65. doi:10.3969/j.issn.1001-3997.2012.08.024 SONG Shaoyun, YIN Fang. Sain vaint principle of meshing in finite elememt method and its application[J]. Mechanical design and manufacturing, 2012(8):63-65. doi:10.3969/j.issn.1001-3997.2012.08.024