超深井高温高压井筒复杂流动压力演变规律研究

doi:10.11885/j.issn.1674-5086.2022.09.17.01

摘要/Abstract

摘要： 超深井钻井过程中，因其高温、高压、高应力及复杂的地层环境，极易发生气侵。若发现不及时，井底压力将持续降低，气侵随之加剧，如此恶性循环，增大井控风险。超深井井筒压力控制的关键技术在于研究复杂多相流流动规律，但目前的研究还不够深入。因此，针对超深井井筒流体高温、高压流变特性展开研究，基于漂移流模型建立了一套超深井全井筒复杂流动数学模型，进行了求解，并以ST8井为例，针对单溢流和溢漏同存进行了模型验证和压力演变规律因素分析。研究结果表明，该模型计算出的立压和套压数据与现场作业测得的数据基本吻合，计算精度较高，可用于描述复杂流动压力演变规律。在相同工况条件下，溢漏同存的压力下降比单溢流下降幅度更大，后果更为严重。此外，密度和排量对井底压力都有影响，其中，密度主要影响静液柱压力，排量主要影响流动摩阻。

关键词: 高温, 高压, 超深井, 复杂流动, 压力演变规律

Abstract: Due to the high temperature, high pressure, high stress and complex formation environment during the drilling of ultra-deep wells, gas invasion is prone to occur. If not discovered in time, the bottom hole pressure will continue to decrease, and gas invasion will intensify, leading to a vicious circle that increases the risk of well control. The key technology of wellbore pressure control lies in the study of complex multiphase flow laws in ultra-deep wells, but the current research is not deep enough. This study focuses on the high-temperature and high-pressure rheological characteristics of the fluids in the ultra-deep wellbore, and establishes a complex mathematical model of the full wellbore flow based on the drift flux model. The model is solved, verified and analyzed using the example of Well ST8 for pure overflow and simultaneous overflow and leakage. Research results show that the calculated standpipe pressure and casing pressure from this model are basically consistent with the field operation data, and the calculation accuracy is high, which can be used to describe the evolution law of complex flow pressure. Under the same working conditions, the pressure drop of the coexisting overflow is higher than that of the overflow condition, and the consequences are more serious. Both density and flow rate have an effect on the bottom hole pressure, in which the density mainly affects the hydrostatic column pressure, and the displacement mainly affects the flow friction.

Key words: high temperature, high pressure, ultra-deep well, complex flow, pressure evolution law

中图分类号:

TE21

邓虎, 唐贵, 张林. 超深井高温高压井筒复杂流动压力演变规律研究[J]. 西南石油大学学报(自然科学版), 2023, 45(4): 111-120.

DENG Hu, TANG Gui, ZHANG Lin. A Study on Evolution Law of Complex Flow Pressure in Ultra-deep Wells with High Temperature and High Pressure[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2023, 45(4): 111-120.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://journal15.magtechjournal.com/Jwk_xnzk/CN/10.11885/j.issn.1674-5086.2022.09.17.01

http://journal15.magtechjournal.com/Jwk_xnzk/CN/Y2023/V45/I4/111

参考文献

[1] 王建云,杨晓波,王鹏,等. 顺北碳酸盐岩裂缝性气藏安全钻井关键技术[J]. 石油钻探技术, 2020, 48(3):8-15. doi:10.11911/syztjs.2020003 WANG Jianyun, YANG Xiaobo, WANG Peng, et al. Key technologies for the safe drilling of fractured carbonate gas reservoirs in the Shunbei oil and gas field[J]. Petroleum Drilling Techniques, 2020, 48(3):8-15. doi:10.11911/syztjs.2020003
[2] MENG Yingfeng, XU Chaoyang, WEI Na, et al. Numerical simulation and experiment of the annular pressure variation caused by gas kick/injection in wells[J]. Journal of Natural Gas Science and Engineering, 2015, 22:646-655. doi:10.1016/j.jngse.2015.01.013
[3] 徐朝阳,孟英峰,魏纳,等. 气侵过程井筒压力演变规律实验和模型[J]. 石油学报, 2015, 36(1):120-126. doi:10.7623/syxb201501015 XU Chaoyang, MENG Yingfeng, WEI Na, et al. Experimental simulation and numerical modeling of dynamic variations in wellbore pressure during gas-kicks[J]. Acta Petrolei Sinica, 2015, 36(1):120-126. doi:10.7623/syxb-201501015
[4] YIN Bangtang, LIU Gang, LI Xiangfang. Multiphase transient flow model in wellbore annuli during gas kick in deepwater drilling based on oil-based mud[J]. Applied Mathematical Modelling, 2017, 51:159-198. doi:10.10-16/j.apm.2017.06.029
[5] SUN Baojiang, GUO Yanli, SUN Wenchao, et al. Multiphase flow behavior for acid-gas mixture and drilling fluid flow in vertical wellbore[J]. Journal of Petroleum Science and Engineering, 2018, 165:388-396. doi:10.1016/j.petrol.2018.02.016
[6] YOU J, RAHNEMA H. Numerical modeling of multiphase steam flow in wellbore[J]. Journal of Petroleum Science and Engineering, 2018, 164:259-277. doi:10.1016/j.petrol.2018.01.070
[7] FANG Qiang, MENG Yingfeng, WEI Na, et al. A hydraulic model for multiphase flow based on the drift flux model in managed pressure drilling[J]. Energies, 2019, 12(20):3930. doi:10.3390/en12203930
[8] LIAO Youqiang, SUN Qian, WANG Zhiyuan, et al. Modeling of wellbore multiphase flow with free gas influx during horizontal drilling in marine hydrate reservoirs[J]. Journal of Natural Gas Science and Engineering, 2022, 97:104375. doi:10.1016/j.jngse.2021.104375
[9] 唐贵,孟英峰,王存新,等. 气体钻井过程中井内不稳定流动与现场试验研究[J]. 天然气工业, 2005, 25(2):75-77, 209. doi:10.3321/j.issn:1000-0976.2005.02.024 TANG Gui, MENG Yingfeng, WANG Cunxin, et al. Borehole gas unsteady flow in the process of gas drilling and its field tese study[J]. Natural Gas Industry, 2005, 25(2):75-77, 209. doi:10.3321/j.issn:1000-0976.2005.02.024
[10] SHI H, HOLMES J A, DURLOFSKY L J, et al. Drift-flux modeling of multiphase flow in wellbores[C]. SPE 84228-MS, 2003. doi:10.2523/84228-MS
[11] 窦亮彬,李根生,沈忠厚,等. 注CO₂井筒温度压力预测模型及影响因素研究[J]. 石油钻探技术, 2013, 41(1):76-81. doi:10.3969/j.issn.1001-0890.2013.01.015 DOU Liangbin, LI Gensheng, SHEN Zhonghou, et al. Wellbore pressure and temperature prediction model and its affecting factors for CO₂ injection wells[J]. Petroleum Drilling Techniques, 2013, 41(1):76-81. doi:10.3969/j.issn.1001-0890.2013.01.015
[12] WAN Liping, MENG Yingfeng, LI Yongjie, et al. Corrosion investigation and prevention of diesel tail gas underbalanced drilling[C]. SPE 100667-MS, 2006. doi:10.2118/100667-MS
[13] AL-ANAZI B D, PAZUKI G R, NIKOOKAR M. et al. The prediction of the compressibility factor of sour and natural gas by an artificial neural network system[J]. Petroleum Science and Technology, 2011, 29(4):325-336. doi:10.1080/10916460903330080
[14] ELSHARKAWY A M. Efficient methods for calculations of compressibility, density and viscosity of natural gases[J]. Fluid Phase Equilibria, 2004, 218(1):1-13. doi:10.1080/10916460903330080
[15] 孙晓峰,姚笛,孙士慧,等. 基于漂移流动模型的水平井岩屑床高度瞬态计算新方法[J]. 天然气工业, 2022, 42(5):85-92. doi:10.3787/j.issn.1000-0976.2022.05.009 SUN Xiaofeng, YAO Di, SUN Shihui, et al. A new transient calculation method of cuttings bed thickness based on drift flow model[J]. Natural Gas Industry, 2022, 42(5):85-92. doi:10.3787/j.issn.1000-0976.2022.05.009
[16] 邓虎,贾利春. 四川盆地深井超深井钻井关键技术与展望[J]. 天然气工业, 2022, 42(12):82-94. doi:10.3787/j.issn.1000-0976.2022.12.009 DENG Hu, JIA Lichun. Key technologies for drilling deep and ultra-deep wells in the Sichuan Basin:Current status, challenges and prospects[J]. Natural Gas Industry, 2022, 42(12):82-94. doi:10.3787/j.issn.1000-0976.2022.12.009
[17] 阎超,屈峰,赵雅甜,等. 航空航天CFD物理模型和计算方法的述评与挑战[J]. 空气动力学学报, 2020, 38(5):829-857. doi:10.7638/kqdlxxb-2020.0072 YAN Chao, QU Feng, ZHAO Yatian, et al. Review of development and challenges for physical modeling and numerical scheme of CFD in aeronautics and astronautics[J]. Acta Aerodynamica Sinica, 2020, 38(5):829-857. doi:10.7638/kqdlxxb-2020.0072
[18] XIAO Dong, MENG Yingfeng, LI Gao, et al. Development of a mathematical model and experimental validation of borehole instability due to gravity displacement during drilling in a fractured formation[J]. Journal of Petroleum Science and Engineering, 2018, 168:217-225. doi:10.1016/j.petro1.2018.05.030
[19] 王存新,许佳欣,李勇,等. 窄安全密度窗口重力置换漏喷函数研究[J]. 西南石油大学学报(自然科学版), 2021, 43(6):201-208. doi:10.11885/j.issn:1674-5086.2020.10.31.01 WANG Cunxin, XU Jiaxin, LI Yong, et al. The leakage function of gravity displacement in the narrow safety density window[J]. Journal of Southwest Petroleum University (Science & Technology Edition), 2021, 43(6):201-208. doi:10.11885/j.issn:1674-5086.2020.10.31.01
[20] 舒刚,孟英峰,李皋,等. 重力置换式漏喷同存机理研究[J]. 石油钻探技术, 2011, 39(1):6-11. doi:10.3969/j.issn.1001-0890.2011.01.002 SHU Gang, MENG Yingfeng, LI Gao, et al. Mechanism of mud loss and well kick due to gravity displacement[J]. Petroleum Drilling Techniques, 2011, 39(1):6-11. doi:10.3969/j.issn.1001-0890.2011.01.002
[21] 马骁,王磊,胡勇科,等. 浅析溢漏同存复杂问题的防治技术——以XX13-1519井为例[J]. 石油地质与工程, 2021, 35(6):118-121. doi:10.3969/j.issn.1673-8217.2021.06.024 MA Xiao, WANG Lei, HU Yongke, et al. Analysis on prevention and control technology of complex problems in drilling such as spillage and leakage exist together:By taking XX13-1519 Well as an example[J]. Petroleum Geology and Engineering, 2021, 35(6):118-121. doi:10.3969/j.issn.1673-8217.2021.06.024
[22] 王军,范翔宇,贺立勤,等. 喷漏同存条件下堵漏压井技术——以四川盆地九龙山构造龙探1井为例[J]. 天然气工业, 2019, 39(1):106-112. doi:10.3787/j.issn.1000-0976.2019.01.012 WANG Jun, FAN Xiangyu, HE Liqin, et al. Well killing and plugging technology under the coexistence of blowout and circulation loss:A case study on Well Longtan 1 in the Jiulongshan structure, Sichuan Basin[J]. Natural Gas Industry, 2019, 39(1):106-122. doi:10.3787/j.issn.1000-0976.2019.01.012
[23] 万云,何建中,张勇,等. 川渝地区井漏分析及处理工艺研究[J]. 油气田地面工程, 2009, 28(6):26-27. doi:10.3969/j.issn.1006-6896.2009.06.013 WAN Yun, HE Jianzhong, ZHANG Yong, et al. Research on analysis and treatment of lost circulation in Chuanyu Area[J]. Oil-Gasfield Surface Engineering, 2009, 28(6):26-27. doi:10.3969/j.issn.1006-6896.2009.06.013
[24] 孔祥伟,林元华,邱伊婕. 控压钻井重力置换与溢流气侵判断准则分析[J]. 应用力学学报, 2015, 32(2):317-322. doi:10.11776/cjam.32.02.A012 KONG Xiangwei, LIN Yuanhua, QIU Yijie. Research of mechanism for the gas invasion and gravity replacement in drilling operations[J]. Chinese Journal of Applied Mechanics, 2015, 32(2):317-322. doi:10.11776/cjam.32.02.A012
[25] 张兴全,周英操,刘伟,等. 欠平衡气侵与重力置换气侵特征及判定方法[J]. 中国石油大学学报(自然科学版), 2015, 39(1):95-102. doi:10.3969/j.issn.1673-5005.2015.01.014 ZHANG Xingquan, ZHOU Yingcao, LIU Wei, et al. A method for characterization and identification of gas kicks caused by underbalanced pressure and gravity displacement[J]. Journal of China University of Petroleum, 2015, 39(1):95-102. doi:10.3969/j.issn.1673-5005.20-15.01.014